Product ID:ANT-ICING AND D-ICING DEFROSTING FLUID
MSDS Date:07/09/1986
FSC:6850
NIIN:01-281-0338
MSDS Number: BNWFB

CSD INC.

5 HACKBERRY LANE
CONROE, TX 77305
US

Emergency Phone: 409-756-1065

Info Phone: 409-756-1065

Preparer: DOD-HMIS (DGSC-SSH)

Cage: JO933

CSD INC.

687 CONROE, TX 77305 US

Telephone: 409-756-1065

Cage: JO933

PROPYLENE GLYCOL

CAS: 57-55-6

RTECS: TY2000000

INHIBITORS

DIBASIC POTASSIUM PHOSPHATE-PER MIL-A-8243D

Fraction By Weight: 1.0%

L-A-8243D

Fraction By Weight: 0.50%

SODIUM SALT OF TOLYLTRIAZOLE-PER MIL-A-8243D

Fraction By Weight: 0.50%

LD50 LC50 Mixture:LD50 ORAL RAT=20MG/KG PROPYLENE GLYCOL
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE MINOR IRRITATION.NO
CHRONIC EFFECTS ARE EXPECTED IN NORMAL USE.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:EYES:REDNESS,STINGING SENSATION.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING EYE
CONDITIONS MAY BE AT INCREASED RISK FROM EXPOSURE.

First Aid:EYES:IMMEDIATELY!RINSE WITH CLEAN WATER FOR 20-30 MINUTES.GET
MEDICAL ATTENTION.INGEST:GET PROMPT QUALIFIED MEDICAL
ATTENTION.INHAL:NOT A ROUTE OF ENTRY.SKIN:REMOVE CONTAMINATED
CLOTHING;WASH WITH SOA P AND WATER.

Flash Point Method:COC
Flash Point:255F,124C
Lower Limits:2
Upper Limits:13.
Extinguishing Media:DRY CHEMICAL,CARBON DIOXIDE,ALCOHOL FOAM TYPE,WATER
SPRAY OR FOG.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.USE WATER SPRAY FOR COOLING;AVOID
FROTHING/STEAM EXPLOSION.USE SAFE DISTANCE.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR,CAN TRAVEL
DISTANCES ALONG THE GROUND,AND FLASHBACK AT THE SOURCE.BURNING
LIQUID MAY FLOAT ON WATER.

Spill Release Procedures:ELIMINATE SOURCES OF IGNITION.PRODUCT SLIPPERY
WHEN SPILLED.SPREAD GRANULAR COVER ON AREA.BIODEGRADABLE ON
WATER.CONTAIN SPILL.
Neutralizing Agent:NONE

Handling and Storage Precautions:STORE IN TIGHTLY SEALED
CONTAINERS,AWAY FROM HEAT,MOISTURE AND STRONG OXIDIZERS.STORE BELOW
200F.
Other Precautions:DO NOT REUSE EMPTY CONTAINERS.

Respiratory Protection:NOT NEEDED IN NORMAL SERVICE.USE WITH ADEQUATE
VENTILATION.
Ventilation:LOCAL EXHAUST.
Protective Gloves:RUBBER,PVC
Eye Protection:CHEMICAL SPLASH GOGGLES;FACE SHIELD.
Other Protective Equipment:NONE SHOULD BE NORMALLY NEEDED. WEAR
IMPERVIOUS APRON/CLOTHING IF SPLASHING MAY OCCUR.
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICE. AVOID
UNNECESSARY CONTACT. WASH THOROUGHLY BEFORE EATING OR DRINKING.
Supplemental Safety and Health
PRIOR TO CHANGING THIS RECORD ON 93361,THIS RECORD STATED THAT THIS WAS
AN ETHYLENE GLYCOL FORMULA.CTDF CONFIRMS THAT TIS IS
MIL-A-8243D;TY1.MILSPEC STATES THAT THIS IS A PROPLYENE GLYCOL
FORMULA.

HCC:N1
Boiling Pt:B.P. Text:268F,131C
Vapor Pres:<0.1
Spec Gravity:1.047
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID,CHARACTERISTIC ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURE AND OPEN FLAMES.
Hazardous Decomposition Products:CARBOON DIOXIDE AND OTHER HARMFUL
GASES.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.SOLUTIONS SHOULD BE BIODEGRADABLE.INCINERATION
MAY BE AN OPTION(BURN CONCENTRATED LIQUID OR MIX WITH A LOW
VISCOCIY FUEL-AVOID FLAMEOU TS).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.